MULTI GLEAM - SAFETY DATA SHEET
1. IDENTIFICATION OF THE SUBSTANCE / PREPARATION AND COMPANY.
| Product name: | Multi Gleam |
| Intended use: | Glass Cleaner |
| Manufacturer: | ULTRACHEM SYSTEMS LTD., |
| Address: | Raheen, Brittas, Co. Dublin. |
| Telephone: | 4582611 / 2 |
| Telefax: | 4582613 |
| Emergency Telephone: | 087.2557.389./ 087.2557.390 |
2. COMPOSITION / INFORMATION ON INGREDIENTS.
| INGREDIENT NAME | CAS NO. (class) | HEALTH % | RISK (R No.) | CONTENTS |
| De - Ionised Water | > 50 | |||
| Propan - 2 - ol | 67-63-0 | None | None | 25 - 50 |
| Surfactants | <1 | |||
| Perfume / Re - Odourant: | <1 | |||
| Ammonium Hydroxide (Ammonia Solution) | 1336 - 21 - 6 | C | 34 - 37 | <1 |
| Butane | 106 - 97 - 8 | None | None | 1 - 5 |
| Propane | 74 - 98 - 6 | None | None | 1 - 5 |
3. HAZARDS IDENTIFICATION.
| Eye contact: | Irritating to eyes. |
| Skin contact: | Slight skin irritant. Prolonged or repeated can cause dermatitis. |
| Inhalation: | High levels of vapour / mist cause dizziness. Can cause irritation of the respiratory tract. |
| Ingestion: | Accidental ingestion is an unlikely event. |
4. FIRST AID MEASURES.
| Eye contact: | Contact lenses should be removed. Irrigate copiously with clean, fresh water for at least 10 minutes, holding the eyelids apart, and seek medical advice. |
| Skin contact: | Remove contaminated clothing. Wash skin thoroughly with soap and water or use a proprietary skin cleaner. Do NOT use solvents or thinners. If in doubt, seek medical advice. |
| Inhalation: | Remove to fresh air, keep the patient warm and at rest. If breathing is irregular or has stopped, administer artificial respiration. Give nothing by mouth. If unconscious, place in the recovery position and seek medical advice. |
| Ingestion: | If accidentally swallowed, obtain immediate medical attention. Keep at rest. Do NOT induce vomiting. |
5. FIRE - FIGHTING MEASURES.
| Extinguishing media: | Alcohol resistant foam; CO2; powder; water spray / mist |
| Do not use: | Water jet. |
| Special fire fighting procedures: | Fire exposed containers should be sprayed with water to lessen risk of explosion. |
| Unusual fire and explosion hazards: | Fire will produce dense black smoke containing combustion products which may be a health hazard. Appropriate self - contained breathing apparatus may be required. Run off from fire must not enter drains. |
6. ACCIDENTAL RELEASE MEASURES.
| Procedures for leaks or spillage: | Exclude sources of ignition and ventilate the area. Exclude non - essential personnel. Avoid breathing vapours. Refer to protective measures listed in Section 7 & 8. Contain and collect spillage's with non - combustible absorbent materials, e.g. sand earth, vermiculite, diatomaceous earth and place in a suitable container for disposal in accordance with waste regulations (see Section 13). Do not allow to enter drains or water courses. Clean preferably with a detergent; avoid the use of solvents if the product enters drains or sewers, the local water company should be contacted immediately; in the case of contamination of streams, rivers or lakes, the National Rivers Authority. |
7. HANDLING AND STORAGE.
| Handling: | Vapours are heavier than air and may spread along floors. They may form explosive mixtures with air. Prevent the creation of flammable or explosive concentrations of vapour in air and avoid concentrations higher than the occupational exposure limits. Use only in areas from which all sources of heat, sparks and open flame have been excluded. Avoid skin and eye contact. Avoid inhalation of vapour and spray mist. Smoking, eating and drinking should be prohibited in areas of use and storage. |
| Storage: | Store below 50 Deg. C in a dry, well ventilated place away from sources of heat, ignition and direct sunlight. No smoking. Observe the label precautions. Store separately from strong oxidising agents and strongly alkaline and strongly acidic materials. |
8. EXPOSURE CONTROLS / PERSONAL PROTECTION.
| INGREDIENT NAME | OES / MEL | 8hr TWA | 15min STEL |
| Propan - 2 ol | OES | 400ppm | 500ppm |
| Ammonium Hydroxide (Ammonium Solution) | OES | 25ppm | 35ppm |
| Butane | OES | 600ppm | 750ppm |
| Engineering measures: | Provide adequate ventilation to maintain the flammable vapour concentration well below the lower explosive limit (LEL) and ensure the airborne concentration of substances to which an OES has been assigned is below that OES ( Occupational Exposure Standard). |
| Respiratory protection: | Unlikely to be necessary. |
| Hand protection: | Use of protection gloves is recommended. |
| Eye protection: | Eye protection designed to protect against liquid splashes should be worn. |
| Skin protection: | Cotton or cotton / synthetic overalls are normally suitable. Grossly contaminated clothing should be removed and the skin washed with soap and water or a proprietary skin cleaner. (Sk) denotes product can be absorbed through skin. |
9. PHYSICAL AND CHEMICAL PROPERTIES./
| Physical State: | Aerosol |
| Appearance: | Colourless liquid |
| Odour: | Alcoholic |
| pH: | N/A |
| Boiling point/boiling range: | 81 Deg.C |
| Melting point/ melting range: | <0 Deg.C |
| Flash point: | N/A Deg.C |
| Flammabiltiy: | LEL 0.8 (% vol in air @ 25 Deg. C ) UEL 12.0 |
| Autoflammability: | >400 Deg.C |
| Explosive properties: | None |
| Oxidising properties: | None |
| Can pressure: | 2.75 bar |
| Relative density: | N/A |
| VOC content: | 37 g/100ml |
| Solubility - water: | Soluble |
| Solubility - Solvent: | Soluble in alcohol's. |
| Other data: |
10. STABILITY AND REACTIVITY.
| Stability: | Stable |
| Conditions to avoid: | Avoid naked flames, red hot surfaces, other high temp. sources that may induce thermal decomposition. |
| Incompatibility (Materials to avoid): | Oxidising agents, strong acids, strong alkalis. |
| Hazardous decomposition products: | In a fire, hazardous decomposition products such as smoke, carbon monoxide, carbon dioxide and oxides of nitrogen may be produced. |
11. TOXICOLOGICAL INFORMATION.
| INGREDIENT | LD50(Animal / oral) |
| Propan - ol | 5.8g/kg(Rat) |
| Ammonium Hydroxide (Ammonia Solution) | 0.35g/Kg (Rat) |
12. ECOLOGICAL INFORMATION.
There is no data available on the product itself.13 . DISPOSAL CONSIDERATIONS.
Do not allow into drains or water courses or dispose of where ground or surface waters may be affected.14 . TRANSPORT INFORMATION.
| CCCN: | 3403 99 90 |
| UN NO.: | 1950 |
| IMDG: | 9022 |
| ICAO/IATA: | |
| RID / ADR: |
15. REGULATORY INFORMATION.
| Label for supply: | EXTREMELY FLAMMABLE |
| Risk phrases: | None |
| Safety phrases: | |
| 2: | Keep out of the reach of children. |
| 16: | Keep away from sources of ignition - No Smoking. |
| 23: | Do not breathe vapour / spray. |
| 51: | Use only in well ventilated areas. |
| Regulatory references: | The Chemicals (Hazard Information and Packaging) Regulations 1993 |
16. OTHER INFORMATION.
The information contained in this data sheet is provided in accordance with the requirements of the Chemicals (Hazard Information and Packaging) Regulations. It does not constitute the user's own assessment of workplace risks as required by other health and safety legislation. The provisions of the Health & Safety at Work etc. and the Control of Substances Hazardous to Health Regulations apply to the use of this product at work.Date of issue of original: 08.03.94
Revision: 1
Revision dated: 24.06.94
This product should be stored, handled and used in accordance with good industrial practices and in conformity with legal regulations. The information contained herein is based on the current state of our knowledge and is intended to describe products from the point of view of safety requirements and thus should not be construed as guaranteeing specific properties. For further information contact the office.